Turbosmart BOOST CONTROLLERS - Single Stage Boost Controller Manuel d'utilisateur télécharger pdf

------------------------------------------------------------------------------------------------------------------------

IMPORTANT NOTES ON YOUR BOOST CONTROLLER

• Use only silicone hose that is the correct size and pressure rating for your application when fitting your boost controller – other

hoses will be effected by heat and will eventually crack or split which could cause excessive boost pressure and engine damage

• Ensure that all plumbing is secured with clamps

• Your boost controller should be mounted at least 100mm from any heat source

• A Turbosmart Fuel Cut Defender may need to be used in conjunction with your boost controller – refer to www.turbosmart.com.au

• The boost dial has a left handed thread, be sure not to over tighten as this will damage the boost controller

RECOMMENDATIONS

• Turbosmart recommends that the Air Fuel ratio is checked once boost pressure is set

• Turbosmart recommends that boost pressure is set using a Dynamometer and not on the street

• Turbosmart recommends that a accurate boost gauge be permanently fitted to the vehicle

• Turbosmart recommends that your boost controller is fitted and adjusted by an appropriately qualified technician

------------------------------------------------------------------------------------------------------------------------

HOW TO INSTALL YOUR BOOST CONTROLLER

TOOLS REQUIRED

General mechanic tools

ELECTRICAL CONNECTION

• The Blue wire is positive and the Brown wire is negative

• Extend and connect the Blue wire through the switch to a fused 12 volt ignition supply – Important, failure to connect to an ignition

supply may cause the battery to go flat and may result in damage to the product

• Check that the power source can accept an additional 1amp load

• Connect the brown wire, with crimp supplied, to a solid ground point on the chassis

1) INTERNAL WASTEGATE SETUP

• Allow the engine to cool down before installing your boost controller

• Locate the pressure source port and the wastegate actuator port on the turbocharger assembly (refer drawing 1)

• Remove the factory boost control solenoid if fitted from the boost pressure supply port while leaving the solenoid connected to the

ECU

• Install the SSBC Tee piece in the wastegate pressure line with the wastegate arrow pointing towards the wastegate actuator

• If your wastegate actuator has additional ports, these will need to be blocked

• Secure all silicone hose ends with hose clamps

• Mount your boost controller bracket onto the vehicle, and then attach the boost controller onto the bracket with the supplied screws

• Make sure the boost dial is turned completely anti-clockwise before making adjustments.

Product Name: SINGLE STAGE

Product Description: Single stage boost controller

Product Number: TS-0104-1001

Wastegate actuator port

SSBC Tee piece

Pressure source port

(Located before the

throttle body)

Compressor

Boost controller

Wastegate Arrow

Drawing 1

Boost dial

1 2 3 4

Résumé du contenu

Page 1

1 ------------------------------------------------------------------------------------------------------------------------ IMPORTANT NOTES ON YOUR B

Page 2

2 HOW TO INSTALL YOUR BOOST CONTROLLER cont. 2) EXTERNAL WASTEGATE SETUP • Allow the engine to cool down before installing your boost controller •

Page 3 - TROUBLE SHOOTING

3 SETTING BOOST PRESSURE IMPORTANT NOTES ON BOOST PRESSURE ADJUSTMENT • Adjustment to your boost controller is made by rotating the Boost Dial •

Page 4 - Happy motoring!

4 DO NOT USE ANY TURBOSMART PRODUCT UNTIL YOU HAVE CAREFULLY READ AND UNDERSTOOD THE FOLLOWING AGREEMENT. Please call if you have any question

Commentaires sur ces manuels

Pas de commentaire

Turbosmart BOOST CONTROLLERS - Single Stage Boost Controller Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Turbosmart BOOST CONTROLLERS - Single Stage Boost Controller. Turbosmart BOOST CONTROLLERS - Single Stage Boost Controller User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la voiture Turbosmart BOOST CONTROLLERS - Single Stage Boost Controller